Product ID:SPEED-E-NAMEL MED GRAY (12 OZ), 0468WZ
MSDS Date:03/10/1995
FSC:8010
NIIN:00N072315
MSDS Number: CBXYK

ZYNOLYTE PRODUCTS CO

2320 E DOMINGUEZ
CARSON, CA 90749
US

Emergency Phone: 303-623-5716;800-424-9300(CHEMTREC)

Info Phone: 310-513-0700

Preparer: JOHN R. KORDOSH

Cage: 25461

ZYNOLYTE PRODUCTS CO

6244 CARSON, CA 90749 US

Telephone: 310-513-0700

Cage: 25461

184 @ 68F

CAS: 67-64-1

RTECS: AL3150000

Fraction By Weight: 30%

OSHA PEL 1000 PPM

ACGIH TLV: 750 PPM; 1000 STEL

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

22 @ 68F

CAS: 108-88-3

RTECS: XS5250000

Fraction By Weight: 18%

OSHA PEL 200 PPM

ACGIH TLV: 50 PPM, S

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

200 @ 100F

CAS: 74-98-6

RTECS: TX2275000

Fraction By Weight: 15%

OSHA PEL 1000 PPM

ACGIH TLV: ASPHYXIANT

37 @ 100F

CAS: 106-97-8

RTECS: EJ4200000

Fraction By Weight: 10%

OSHA PEL 800 PPM

ACGIH TLV: 800 PPM

LACOLENE; (ALIPHATIC PETROLEUM DISTILLATE). BP

CAS: 64742-89-8

Fraction By Weight: 5%

OSHA PEL 300 PPM (MFR)

ACGIH TLV: 300 PPM (MFR)

72 @ 100F

CAS: 75-28-5

RTECS: TZ4300000

Fraction By Weight: 5%

OSHA PEL N/K

ACGIH TLV: N/K

5.1 @ 68F

CAS: 1330-20-7

RTECS: ZE2100000

Fraction By Weight: 3%

OSHA PEL 100 PPM

ACGIH TLV: 100 PPM; 150 STEL

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

CONSULTATION FROM APPROP HLTH PROFESSINALS

RTECS: 9999999ZZ

. REPORTS HAVE ASSOC RPTD & PRLNGD OVEREXP TO SOLV

RTECS: 9999999ZZ

RATS HAVE SHOWN PETRO DISTILLS CAUSE KIDNEY DMG &

RTECS: 9999999ZZ

STUDIES W/GUINEA PIGS, DOGS OR MONKEYS. SEVERAL

RTECS: 9999999ZZ

A SIGNIFICANT INCREASE OF KIDNEY DMG OR AN INCREASE

RTECS: 9999999ZZ

EATING OR SMKNG. DO NOT STORE >120F.

RTECS: 9999999ZZ

SUNLIGHT TO AVOID BURSTING. DO NOT SPRAY NEAR FIRE

RTECS: 9999999ZZ

DRY COATING WITHOUT A NIOSH APPROVED

RTECS: 9999999ZZ

EXHAUSTED. FOLLOW RESPIRATOR MANUFACTURER'S

RTECS: 9999999ZZ

USE ONLY EXPLOSION PROOF EQUIPMENT WITH FLAMMABLE

RTECS: 9999999ZZ

PROTECTIVE CREAMS ARE NOT RECOMMENDED FOR

RTECS: 9999999ZZ

OF SPILL, SPLASH OR EXCESS OVERSPRAY. DO

RTECS: 9999999ZZ

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:INHAL: MAY CAUSE NOSE & THROAT IRRIT.
MAY CAUSE NERVOUS SYS DEPRESS CHARACT BY FOLLOWING PROGRESSIVE
STEPS: HDCH, DIZZ, NAUS, STAG GAIT, LASSITUDE, LOSS OF
COORDINATION, CONFUSION, UNCON. SKIN/EYES: M AY CAUSE IRRIT OR
BURNING OF EYES. RPTD/PRLNGD LIQ CNTCT MAY CAUSE SKIN IRRIT
W/DISCOMFORT & DERM. (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: EYE WATERING, HDCH, NAUS, DIZZ, ETC
ARE SIGNS THAT SOLV LEVELS ARE TOO HIGH. ORG SOLVS ARE EASILY
ABSORBED THRU SKIN. SEE INHAL. DRY SKIN REDNESS OR DERM DUE TO
DEFAT ACTION OF SOLVS ARE SIG NS OF EXPOS. INGEST: SEE INHAL: MAY
ALSO RSLT IN GI DISTRESS. THERE IS DANGER OF PETRO DISTILS ENTERING
LUNGS IF(SUPDAT)
Medical Cond Aggravated by Exposure:PREEXISTING EYE, SKIN AND
RESPIRATORY DISORDERS MAY BE AGGRAVATED BY EXPOSURE TO THIS
PRODUCT.

First Aid:INHAL: REMOVE TO FRESH AIR. IF NOT BRTHG, GIVE ARTF RESP,
PREF MOUTH-TO-MOUTH, CALL MD. EYES: IMMED FLUSH W/PLENTY OF WATER
FOR AT LEAST 15 MIN; CALL MD. SKIN: WASH SKIN W/SOAP & WATER. IF
IRRIT OCCUR S, CONTACT MD. INGEST: CALL MD IMMED. HAVE NAMES OF HAZ
INGREDS READY. DO NOT INDUCE VOMIT. KEEP HEAD LOWER THAN WAIST.
ASPIR OF VOMITUS MAY RSLT IN CHEMICAL PNEUMONITIS &/OR PULMONARY
EDEMA.

Flash Point Method:TCC
Flash Point:-256F,-160C
Lower Limits:1%
Upper Limits:13%
Extinguishing Media:FOAM, CARBON DIOXIDE, DRY CHEMICAL.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT . AVOID CONFINED SPACES. WATER MAY BE UNSUITABLE AS AN
EXTINGUISHING MEDIUM.
Unusual Fire/Explosion Hazard:VAPS ARE HVR/AIR & MAY ACCUM IN LOW AREAS
OF POOR VENT OR TRAVEL ALONG GROUND TO REMOTE IGNIT SITES. CONTENTS
ARE UNDER PRESS. KEEP COOL. EXPOS TO HEAT (SUPDAT)

Spill Release Procedures:VENTILATE AREA. REMOVE SOURCES OF IGNITION,
INCLUDING HOT METAL SURFACES. WEAR APPROPRIATE CLOTHING AND GEAR.
PRVENT SKIN CONTACT AND AVOID BREATHING OF VAPOR. CONFINE
IMMEDIATELY AND REMOVE WITH INER T ABSORBENT SUCH AS CLAY OR SAND.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:OBSERVE LABEL PRECS. KEEP AWAY FROM
HEAT, SPKS & OPEN FLAME (IE ALL IGNIT SOURCES). CAP CNTNR AFTER
EACH USE. WASH THORO AFTER HNDLG & BEFORE (ING 14)
Other Precautions:AVOID UNNEC CONTACT. DO NOT TAKE INTERNALLY. DO NOT
PUNCTURE CNTNRS. USE W/ADEQ VENT - DO NOT INHALE VAPS. INTENTIONAL
MISUSE BY DELIB CONC & INHALING VAPS OF THIS PROD MAY BE
HARMFUL/FATAL. DO NOT SA ND, FLAME CUT, BRAZE OR WELD (ING 16)

Respiratory Protection:DO NOT BREATHE VAPS/MISTS. IF TLV, PEL OR OTHER
LIMS ARE EXCEEDED THEN WEAR PROPERLY FITTED VAP & PARTICULATE OR
POS PRESS AIR SUPPLIED RESP APPRVD BY NIOSH FOR USE W/PAINTS DURING
APPLICATION & UNTIL ALL VAPS & SPRAY MISTS ARE (ING 17)
Ventilation:PROVIDE SUFFICIENT VENT IN VOL & PATTERN TO KEEP
CONTAMINANTS BELOW APPLIC OSHA REQS/OTHER SUGGESTED EXPOS LIMS.(ING
18)
Protective Gloves:NEOPRENE GLOVES OR BETTER. (ING 19)
Eye Protection:ANSI APPRVD CHEM WORKERS GOGGLES .
Other Protective Equipment:ANSI APPRVD EYE WASH & DELUGE SHOWER .
APRON, COVERALLS OR WORK CLOTHES. CHANGE CLOTHES & SHOES IN CASE
(ING 20)
Work Hygienic Practices:AS WITH ALL CHEMICAL PRODUCTS, USE CARE IN
HANDLING. DO NOT SMOKE OR EAT WITHOUT FIRST WASHING YOUR HANDS.
Supplemental Safety and Health
EXPLO HAZ: OR SUNLIGHT MAY CAUSE CANS TO BURST & PROPELL CONTENTS.
WATER FROM FOG NOZZS MAY BE HELPFUL IN COOLING UNRUPTURED CNTNRS TO
PVNT PRESS BUILDUP. EFTS OF OVEREXP: SWALLOWED/VOMITED & CAUSING
INFLAMM, DMG OR EVEN DEATH. CHRONIC: TOLUENE APPEARS ON THE NAVY
LIST OF OCCUP CHEM REPRO HAZS. SEEK (ING 9)

Boiling Pt:B.P. Text:>-43F,>-42C
Vapor Pres:SEE INGS
Vapor Density:HVR/AIR
Spec Gravity:0.75 (H*2O=1)
VOC Grams/Liter:5.45
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:AEROSOL CAN.

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, STRONG ACIDS AND BASES, SELECTED AMINES.
Stability Condition to Avoid:NONE REASONABLY FORSEEABLE.
Hazardous Decomposition Products:MAY EMIT FUMES WHEN HEATED TO
DECOMPOSITION. MAY EMIT CARBON MONOXIDE, CARBON DIOXIDE,
UNIDENTIFIED ORGANIC COMPOUNDS.

Waste Disposal Methods:DO NOT ALLOW MATERIAL TO CONTAMINATE GROUND
WATER SYSTEMS. PLACE IN NON-LEAKING CONTAINERS. DISPOSE OF ABSORBED
MATERIAL IN ACCORDANCE WITH ALL FEDERAL, STATE AND LOCAL
REQUIREMENTS. DO NOT INCINERATE IN CLOSED CONTAINERS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.